XLS《安装验收表》

"施工升降机安装验收表(#楼)",,

,,

,,

"工程名称",,

,,

"工程地址",,

"设备型号",,

,,

"备案登记号",,

"设备生产厂",,

,,

"出厂编号",,

"出场日期",,

,,

"安装高度",,

"安装负责人",,

,,

"安装日期",,

"检查结果代号说明",,

,"√=合格=整改后合格*=不合格无=无此项",,

, "检查项目","序号",,

"内容和要求",,

"检查结果","备注" "主要部件","1",,

"导轨架、附墙架连接安装齐全、牢固,位置正确",,

, ,"2",,

"螺栓拧紧力矩达到技术要求,开口销完全撬开",,

, ,"3",,

"导轨架安装垂直度满足要求",,

, ,"4",,

"结构件无变形、开焊、裂纹",,

, ,"5",,

"对重导轨符合使用说明书要求",,

, "传动系统","6",,

"钢丝绳规格正确,未达到报废标准",,

, ,"7",,

"钢丝绳固定和编结符合标准要求",,

, ,"8",,

"各部位滑轮转动灵活、可靠,无卡阻现象",,

, ,"9",,

"齿条、齿轮、曳引轮符合标准要求、保险装置可靠",,

, ,"10",,

"各机构转动平稳、无异常响声",,

, ,"11",,

"各润滑点润滑良好、润滑油牌号正确",,

, ,"12",,

"制动器、离合器动作灵活可靠",,

, "电气系统","13",,

"供电系统正常,额定电压值偏差≤±5%",,

, ,"14",,

"接触器、继电器接触良好",,

, ,"15",,

"仪表、照明、报警系统完好可靠",,

, ,"16",,

"控制、操纵装置动作灵活、可靠",,

, ,"17",,

"各种电气安全保护装置齐全、可靠",,

, ,"18",,

"电气系统对导轨架的绝缘电阻应≥0.

5MΩ",,

, ,"19",,

"接地电阻应≤4Ω",,

, "安全系统","20",,

"防坠安全器在有效标定期限内",,

, ,"21",,

"防坠安全器灵敏可靠",,

, ,"22",,

"超载保护装置灵敏可靠",,

, ,"23",,

"上、下限位开关灵敏可靠",,

, "安全系统","24",,

"上、下极限开关灵敏可靠",,

, ,"25",,

"急停开关灵敏可靠",,

, ,"26",,

"安全钩完好",,

, ,"27",,

"额定载重量标牌牢固清晰",,

, ,"28",,

"地面防护围栏门、吊笼门机电联锁灵敏可靠",,

, "试运行","29",,

"空载","双吊笼施工升降机应分别对两个吊笼进行试运行.是运行中吊笼应启动、制动正常,运行平稳,无异常现象",,

,"30",,

"额定载重量",,

, ,"31",,

"125%额定载重量",,

, "坠落试验","32",,

"吊笼制动后,结构及连接件应无任何损坏或永远变形,且制动距离应符合要求",,

, "验收结论:符合要求,同意使用()验收日期:年月日",,

,,

,,

"总承包单位",,

,,

"参加人员签字盖章",,

"使用单位",,

,,

"参加人员签字盖章",,

"安装单位",,

,,

"参加人员签字盖章",,

"监理单位",,

,,

"参加人员签字盖章",,

"租赁单位",,

,,

"参加人员签字盖章",,

"注:1新安装的施工升降机及在用的施工升降机应至少每3个月进行一次额定载重量的坠落试验;

新安装及大修后的施工升降机应做125%额定载重量试运行;

2对不符合要求的项目应在备注栏具体说明,对要求量化的参数应填实测值.",,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,

,,